15369665500
泰好博游戏 關于我們
產品中心
工程案例
行業動態
資質榮譽
在線留言
聯系我們

(迪瑞夫)金剛砂耐磨地坪 

發布時間:2017/10/27
(迪瑞夫)金剛砂耐磨地坪

   產品說明The Product Description
迪瑞夫彩色耐磨干撒式地面硬化劑由一定顆粒級配的礦物合金骨料或非金屬骨料,特種水泥,其它摻合料和外加劑組成,開袋即可使用。將其均勻地撒布在即將初凝階段的混凝土表面,經專門手段加工,從而使其與混凝土地面形成一個整體,且具有高致密性和著色的高性能耐磨地面。
Duraf color wear-resisting dry and type curing agent on the ground by a certain grain size distribution of mineral alloy aggregate or nonmetal aggregate, special cement, admixture and other admixtures, open bags can be used. It evenly over the initial setting stage concrete surface, processed by special means, making it the ground with concrete to form a whole, and high performance with high density and color wear-resisting surface.
 
技術指標Technical indicators
符合國家標準:JC/T 906-2002

 

項目
技術指標
檢驗結果
結論
I
II
抗折強度/Mpa
28d
≥11.5
≥13.5
12.5
合格
抗壓強度/Mpa
28d
≥80.0
≥90.0
87.6
合格
表面強度(壓痕直徑),mm
≤3.30
≤3.10
2.7
合格
耐磨度比,%
≥330
≥335
335
合格

 

 
增強混凝土地面的耐磨性,耐沖擊性度。極大提高了混凝土的密度,使其減少起塵,增加了地面的防油性,形成了一個高密度,易清潔,抗滲透的地面。與混凝土地面一起施工,施工工期短。耐久性好,減少了因周期性涂裝或將表面增厚所帶來的費用。
Reinforced concrete ground of wear resistance, resistance to impact. Greatly improve the density
of the concrete, make its reduce dust, increase defense oily ground, forming a high density,
easy to clean, the ground of the resistance to penetration. With the concrete construction,short
construction time limit for a project. Good durability, reduced because of the cyclical coating or will cost brought by the thickening of the surface.
 
產品顏色 Product Colour
水泥色、灰色、綠色、黃色、紅色等。
The cement color, yellow, green, yellow, red, etc
鐵綠Iron green    原色Primary colour   黑色BLACK 中灰Medium grey 淺灰
灰黑   進口鉻綠  孔雀藍     天藍  黃色   鐵紅  淺藍色  桔紅  棕黃 地坪綠
 
適用范圍Scope of application
適用于新澆筑混凝土施工,適用于室內外混凝土表面。
1、  工業廠房、生產車間
2、倉庫、物流中心
3、車庫、停車場
4、超市、賣場
Apply to the new pouring concrete construction, suitable for indoor and outdoor concrete surface.
1, Industrial Workshop, Production Workshop
2, Warehouse , Logistics center
3, Garage, Parking lot
4, Supermarkets, Stores
施工流程The construction process
1、混凝土基礎澆筑
2、找平
3、撒布金剛砂
4、機械抹光
5、涂滾養護劑(養護)
1,Pouring concrete foundation 
2,Leveling
3,Scatter silicon carbide
4,Mechanical finishing
5,Roll coating curing agent(maintenance)
基礎要求
◇ 基層混凝土強度要求達到C25以上,水灰比控制在0.50以下,混凝土塔落度應控制在70-100mm,混
   凝土拌合物盡量減少離析并對泌水有所控制。
◇ 為了確保混凝土拌合物有足夠流動性及利于施工,建議混凝土加適當外加劑。
◇ 基層混凝土應參照優良混凝土的標準進行澆筑和振實,注意尺寸精確并減少浮漿產生。
◇ 硬化劑表面最好同混凝土結構層同時施工,如須同找平層同時施工,建議找平層混凝土采用細   石混凝土,厚度不低于50mm,并考慮配置伸縮鋼筋網。
◇ 特別注意基層混凝土施工塊的邊角部位,保證該處混凝土振搗密實,并應采取額外加強處理。
 
The construction process
      Cardiac grassroots reach more than C25 concrete strength requirements, water cement ratio control in 0.50 the following, concrete tower should be controlled in 70-100 - mm, concrete mixture to minimize segregation and to control bleeding.
      Is left to make sure that the concrete mixture have enough liquidity and conducive to the construction, proposed concrete admixture appropriately.
      Derive concrete at the grass-roots level shall refer to the good of the standard of concrete pouring and vibrating, pay attention to the size precision and reduce the bleeding.
      Cardiac hardener surface layer with concrete structure construction at the same time, the best such as screed-coat construction at the same time, suggest using fine aggregate concrete, concrete leveling layer thickness of not less than 50 mm, and consider the configuration telescopic steel fabric.
      Has to pay special attention to grassroots edge position of the concrete block, ensure it concrete vibratory compaction, and should take extra strengthen processing.